Furnace Replacement Cost in Racine, Wisconsin
Expect to pay $3,300 to $8,100 for furnace replacement in Racine, WI. Most homeowners end up near $5,900, depending on the equipment tier and how much of the old setup can be reused.
Racine Weather and HVAC Load
NOAA's 1991-2020 climate normals put Racine at 7,039 heating degree days and 523 cooling degree days per year. Heating is the bigger job here, and furnaces and heat pumps in Racine put in far more hours than the air conditioner. A normal year brings 119 nights at or below freezing and 6 days over 90°F. Snowfall averages about 41 inches. For a 2,000 sq ft house, this climate points to a heating load somewhere near 70,000 BTU/h. Treat that as a starting number. A Manual J calculation will move it up or down based on insulation and windows.
| Heating degree days / year | 7,039 |
|---|---|
| Cooling degree days / year | 523 |
| Nights at or below 32°F | 119 |
| Days above 90°F | 6 |
| Average low / high | 39.7°F / 54.4°F |
Racine Housing Stock
Half the homes in Racine were built before 1953 (Census ACS median), so the typical house is about 73 years old. Houses that old often still have duct runs sized for an old coal or oil furnace and 60- or 100-amp electrical panels. Both can add cost when new equipment goes in. Owners live in 60.1% of occupied homes, roughly 19,000 households. With a median household income of $55,705 and a median home value of $158,100, local labor rates come out below the national middle in our model.
NOAA storm reports for Racine County show 6 hail days and 12 days with damaging thunderstorm winds over the six years from 2020 to 2025. The largest hail reported was 2.75 inches across. Storms here are more likely to cause power surges than coil damage, so a surge protector on the outdoor unit is worth the small cost.
When Replacement Makes Sense
- Gas or electric bills keep climbing even though usage hasn't changed
- A repair quote runs past a third of the cost of a new unit
- A tech found a cracked heat exchanger, or the CO detector has gone off
- Some rooms stay cold, the burner short-cycles, or the ignitor keeps failing
What Moves the Price
- Permit and inspection fees, which the local building department sets
- Condition of the existing ductwork and any changes it needs
- New PVC venting if you move to a condensing model
- AFUE rating: a basic 80% unit vs. a 96% condensing furnace
- Single-stage, two-stage or modulating gas valve
- BTU size, which should come from a Manual J load calculation
For Racine we raised the national figures about 4%, based on local income, home values and climate-based equipment sizing. Get at least three written quotes; real bids can land outside this range.
What the Quote Should Cover
- Combustion and safety tests
- The new furnace, filter rack and thermostat wiring
- Removing and hauling away the old furnace
- Gas line and vent connections
- The permit and the manufacturer warranty registration
Wisconsin Permits, Efficiency Rules and Rebates
Wisconsin falls in the DOE's North region. New split central air conditioners must meet at least 13.4 SEER2, and heat pumps sold anywhere in the U.S. need 14.3 SEER2 and 7.5 HSPF2. Equipment replacements in Racine generally need a mechanical permit, and a reputable contractor will pull it for you. Ask for their Wisconsin license or registration number and a certificate of insurance with the quote. The federal 25C tax credit ended for equipment installed after December 31, 2025, so incentives now come mostly from utilities and state programs. Check your electric and gas utility's rebate page before you pick equipment.
Before You Hire
- Replace it in early fall if you can. A no-heat emergency in January costs more and leaves you fewer choices.
- Look up utility rebates on 95%+ AFUE units before you buy.
- Ask for the Manual J load calculation in writing. Oversized furnaces are the most common mistake we see.
Get Free Furnace Replacement Quotes in Racine
Tell us where you are and up to three licensed local pros will get in touch. You don't have to hire any of them.
Furnace Replacement Questions from Racine Homeowners
How much is furnace replacement in Racine?
Plan on $3,300 to $8,100, with most jobs near $5,900. Equipment efficiency, house size and the condition of the ducts and wiring decide where your quote falls.
When is the best time to schedule furnace replacement in Racine?
Between late spring and early fall. Racine averages 119 freezing nights a year, and heating calls spike from November through February.
Is a high-efficiency furnace worth it?
In cold climates, a 95%+ AFUE furnace usually earns back the price difference in lower gas bills. Where winters are mild, the payback can take a very long time.
How long does a furnace replacement take?
A straight swap is usually done in one day, somewhere between 4 and 10 hours. Moving to a condensing furnace with new PVC venting can add a few more.
Furnace Replacement Near Racine
Sources: U.S. Census Bureau ACS 5-year estimates 2019-2023 and 2024 population estimates; NOAA NCEI U.S. Climate Normals 1991-2020, station Racine; NOAA Storm Events Database 2020-2025, Racine County. Prices are our estimates, not contractor quotes. Updated 2026.