Furnace Repair in Madison, Wisconsin
Most furnace repair bills in Madison come in between $190 and $810, service call included. The busiest week of the year is usually the first hard freeze, when furnaces that sat idle since spring get switched on.
Compare Free Quotes in Madison
Madison Weather and HVAC Load
In a normal year, Madison racks up 7,096 heating and 639 cooling degree days (NOAA 1991-2020 normals). Heating is the bigger job here, and furnaces and heat pumps in Madison put in far more hours than the air conditioner. On average, Madison gets 157 freezing nights and 10 days above 90°F per year. Snowfall averages about 39 inches. For a 2,000 sq ft house, this climate points to a heating load somewhere near 70,000 BTU/h. Treat that as a starting number. A Manual J calculation will move it up or down based on insulation and windows.
| Heating degree days / year | 7,096 |
|---|---|
| Cooling degree days / year | 639 |
| Nights at or below 32°F | 157 |
| Days above 90°F | 10 |
| Average low / high | 37.3°F / 57.1°F |
Madison Housing Stock
Half the homes in Madison were built before 1979 (Census ACS median), so the typical house is about 47 years old. A lot of these homes are on their second or third system by now. The ductwork is usually original, and leaky joints are common. Madison has roughly 59,000 owner-occupied homes, or 46.6% of households. Homes here have a median value of $346,900 and households a median income of $76,983. Those two numbers drive the labor adjustment in our estimate.
Between 2020 and 2025, NOAA's Storm Events Database logged 24 hail days and 30 days with damaging thunderstorm winds in Dane County. The largest hail reported was 2.5 inches across. Hail flattens the thin aluminum fins on condenser coils and cuts airflow. After a big storm, take a look at the outdoor unit; homeowners insurance often covers the damage. Dane County also had 7 tornado days in that period.
Symptoms Worth a Service Call
- A yellow or flickering flame instead of a steady blue one
- Cold air coming out of the vents
- The thermostat calls for heat and nothing happens
- Banging, squealing or rattling from the furnace
- The burners light, then shut off a few seconds later
What Moves the Price
- Night, weekend or holiday rates
- The diagnostic or service call fee
- Whether the part is still under the manufacturer warranty
- The furnace's age and brand, which affect parts availability
- Which part failed: a flame sensor costs far less than a control board or blower motor
For Madison we raised the national figures about 24%, based on local income, home values and climate-based equipment sizing. Get at least three written quotes; real bids can land outside this range.
What the Quote Should Cover
- Replacing the part that failed
- A diagnostic check
- A safety and combustion check
- A test run through a full heating cycle
Wisconsin Licensing and Efficiency Rules
Wisconsin falls in the DOE's North region. New split central air conditioners must meet at least 13.4 SEER2, and heat pumps sold anywhere in the U.S. need 14.3 SEER2 and 7.5 HSPF2. Most repairs don't need a permit. Anyone who opens the refrigerant circuit does need EPA Section 608 certification, and in Wisconsin the company should carry a state license or registration. Ask for both.
Before You Hire
- If the furnace is past 15, ask the tech to price both a repair and a replacement.
- Ask whether the diagnostic fee comes off the repair bill.
- Check the filter, the thermostat batteries and the breaker first. Those three cause a surprising number of no-heat calls.
Get Free Furnace Repair Quotes in Madison
Tell us where you are and up to three licensed local pros will get in touch. You don't have to hire any of them.
Furnace Repair Questions from Madison Homeowners
What does furnace repair cost in Madison?
Most bills land between $190 and $810, including the service call. A typical visit is about $530. Night and weekend calls cost more.
What is the most common furnace repair?
Cleaning a dirty flame sensor or replacing a cracked hot-surface ignitor. They're also two of the cheapest repairs.
Should I repair or replace my furnace?
Here's a rule many techs use: multiply the furnace's age by the repair quote. If the number is over $5,000, replacing it usually makes more sense.
Furnace Repair Near Madison
Sources: U.S. Census Bureau ACS 5-year estimates 2019-2023 and 2024 population estimates; NOAA NCEI U.S. Climate Normals 1991-2020, station Uw Arboretum Madison; NOAA Storm Events Database 2020-2025, Dane County. Prices are our estimates, not contractor quotes. Updated 2026.